2000 ford taurus fuel pump replacement cost

#2000 ford taurus fuel pump replacement cost install
#2000 ford taurus fuel pump replacement cost Patch
#2000 ford taurus fuel pump replacement cost full
#2000 ford taurus fuel pump replacement cost code

caulking / good silicone caulk / auto body caulk - around edges of cover plate - whatever, you get the idea. TAR down the plate at it's edges with that thick black rubberized undercoating (messy, if you need to re-open, but will do the job). Find many great new & used options and get the best deals for Carter Electric Fuel Pump for 2002 Ford Taurus 3. two sided adhesive foam tape around edges of formed cover plate, like what is used to put up posters on wall etc. then secure down cover around edges with good tape or a few very short metal screws if you have the clearance and won't puncture or screw into anything below. thin foam weather stripping with one sided adhesive. Secure down somehow safe, that can be re-opened later if necessary. then the fuel pressure sensor has failed The auto repair labor rates vary.

#2000 ford taurus fuel pump replacement cost code

The cost of having the fuel pump replaced by a mechanic will generally be between 260 1009, and the price will vary greatly depending on the type of car you own. Trouble code P0191 means: Fuel Rail Pressure Sensor Range/Performance Nov 04. I'd just form a sheet steel cover, a little larger than the hole. Without a properly functioning fuel pump, the engine won’t run.

#2000 ford taurus fuel pump replacement cost install

I bought a Ford module a few years ago to install in my 2006 because it was a really good deal. Thanks for the tip on the color of the label on the pump module versus the tank size. Also if you didn't have a floor jack to jack up the car and lower the tank. Also it you didn't have the work area to jack up a car without people complaining.

#2000 ford taurus fuel pump replacement cost full

I could see if you had an unexpected failure with a full tank that this would maybe be desirable. then the fuel pump goes out cause I can't drive it.

Average repair cost is 1,250 at 85,600 miles. I also see that no matter what you have to cut the wires because you need the length of wire to pull up the module out of the tank even it you just replace the pump. The 2000 Ford Taurus has 7 problems reported for transmission is slipping.

#2000 ford taurus fuel pump replacement cost Patch

I am thinking the time to cut the metal, cut the wires, resolder the wires, fab the metal patch and seal and install a metal patch, takes a decent amount of time. I cut the hose off the tank but also installed a new tank. On the one Taurus installed a new filler hose to speed the install. I jack the car and put 6 x 6 wood blocks under the rear wheels. I am thinking it may be just as easy to just take the two bolts from the straps and two hose clamps. I praise your efforts on cutting the hole. the average replacement cost is around 2,000 and you cant do it. It gets easier each time which only takes a few hours after the first time. she unable to stop it except crash into biggest tree on the block. One of these I dropped the tank three times, once to replace the original pump, then a few years latter to replace the tank due to leaks and then a year latter to replace the pump again. I have dropped my tanks on my two 2001 Taurus. What should I expect dollar wise I would expect to spend about 120 on parts and about 2 hours worth of labor. Thermo-Tec 13575 Adhesive Backed Aluminized Heat Barrier, 12' x 24' Fuel Pump Module Assembly 212.00 Fuel Filter 10.99 Standard Labor Time Required Replace Fuel Pump 2.1 Hours Replace Fuel Filter 0.6 Hours 2000 Ford Windstar 0 helpful 1 answer My 2000 ES300 needs a fuel pump. You may use self adhesive heat barrier to cover the hole. (See the 1st Pic, cut out hole still has 2 inches attached to the seat) When soldering the wire, make sure you do not cut any strands of the wires.įinally do not fully cut the sheet metal, leave 2 inches attached so you can fold back after the job. Hard part is removing the metal retainer ring. (I ordered red label for my 16 gal tank which cause inaccurate fuel gauge reading. Red label (Motorcraft PFS244) is for 18 gal tank and white label (Motorcraft PFS243) is for 16 gal tank. Also I have to cut the wires since my fuel pressure regulate (which is build in with the pump assembly) was bad and I need to install the whole assembly.īe careful, there are two types of assembly.

I use metal snipper to cut the hole to avoid the power tool sparks. Here is how: Pictures worth thousand words.

Subject car is 2000 Ford Taurus OHV 12V with VIN 8 digit U. I was inspired by someone on the you tube doing the fuel pump replacement without lowering the fuel tank.